叉车散热器容易出现哪些问题？
发布时间：2023-10-19 点击：153
在炎热的季节，机器使用的叉车已经使用了很长时间，机器会变热!此时，叉车散热器的功能应该发挥毫无保留!叉车散热器很好，叉车可以正常工作!二手叉车提醒您:叉车散热器保养很好，不要让小问题造成大事故!
in the hot season, the forklift used by the machine has been used for a long time, and the machine will get hot! at this time, the function of the forklift radiator should play without reservation! the forklift radiator is very good, and the forklift can work normally! jinan second-hand forklift reminds you: the forklift radiator is well maintained, and don't let small problems cause major accidents!
叉车散热器容易出现以下问题:
forklift radiators are prone to the following problems:
1、润滑不良
1. poor lubrication
冬季，润滑油容易受热变薄，润滑效果明显降低。当曲轴严重转动时，连杆上的轴承等就会烧坏。因此，在夏季运行时，应使用夏季润滑油来代替车辆。同时定期清洗油水散热器，并清洗外部油水，以保证良好的散热。此外，应加强机油滤清器的维护，使机油快速流动，散热。
in winter, the lubricating oil is easy to be heated and thinned, and the lubricating effect is obviously reduced. when the crankshaft rotates seriously, the bearings on the connecting rod will burn out. therefore, in summer operation, summer lubricating oil should be used instead of vehicles. at the same time, clean the oil and water radiator regularly, and clean the external oil and water to ensure good heat dissipation. in addition, the maintenance of the oil filter should be strengthened to make the oil flow quickly and dissipate heat.
2、制动故障
2. brake failure
由于某些制动液的沸点过低，在高温下会蒸发成水蒸气，在制动闸上形成一道气体屏障，从而导致制动失灵。在炎热季节，应检查制动母缸、轮缸、胶圈、老化、制动液粘度和油量，并应及时更换沸点高的制动液，以防油耗过高。完全消除制动系统。空气等等。
because the boiling point of some brake fluid is too low, it will evaporate into water vapor under high temperature, forming a gas barrier on the brake, which will lead to brake failure. in hot season, check the brake master cylinder, wheel cylinder, rubber ring, aging, brake fluid viscosity and oil volume, and replace the brake fluid with high boiling point in time to prevent high oil consumption. completely eliminate the brake system. air, etc.
三是高温软化路面
third, high temperature softened pavement
此外，高温天气使油泥路面变形，路面附加力减小，也大大降低了制动效果。
in addition, the high temperature weather makes the road surface deformed, the additional force of the road surface reduced, and also greatly reduces the braking effect.
简单讲解叉车配件以及零件的清洗
购买叉车必须注意需求
叉车销售公司告诉大家在行驶的时候，需要注意的事项
电动叉车的直流半交流全交流系统该怎么选
电动叉车技术员称对于电动堆高车品牌定位，应该注意以下几点要求：
叉车出租时如何更换叉车的电瓶
电动叉车为什么比柴油叉车贵？
叉车租赁的电动叉车选交流好还是直流好
in the hot season, the forklift used by the machine has been used for a long time, and the machine will get hot! at this time, the function of the forklift radiator should play without reservation! the forklift radiator is very good, and the forklift can work normally! jinan second-hand forklift reminds you: the forklift radiator is well maintained, and don't let small problems cause major accidents!
叉车散热器容易出现以下问题:
forklift radiators are prone to the following problems:
1、润滑不良
1. poor lubrication
冬季，润滑油容易受热变薄，润滑效果明显降低。当曲轴严重转动时，连杆上的轴承等就会烧坏。因此，在夏季运行时，应使用夏季润滑油来代替车辆。同时定期清洗油水散热器，并清洗外部油水，以保证良好的散热。此外，应加强机油滤清器的维护，使机油快速流动，散热。
in winter, the lubricating oil is easy to be heated and thinned, and the lubricating effect is obviously reduced. when the crankshaft rotates seriously, the bearings on the connecting rod will burn out. therefore, in summer operation, summer lubricating oil should be used instead of vehicles. at the same time, clean the oil and water radiator regularly, and clean the external oil and water to ensure good heat dissipation. in addition, the maintenance of the oil filter should be strengthened to make the oil flow quickly and dissipate heat.
2、制动故障
2. brake failure
由于某些制动液的沸点过低，在高温下会蒸发成水蒸气，在制动闸上形成一道气体屏障，从而导致制动失灵。在炎热季节，应检查制动母缸、轮缸、胶圈、老化、制动液粘度和油量，并应及时更换沸点高的制动液，以防油耗过高。完全消除制动系统。空气等等。
because the boiling point of some brake fluid is too low, it will evaporate into water vapor under high temperature, forming a gas barrier on the brake, which will lead to brake failure. in hot season, check the brake master cylinder, wheel cylinder, rubber ring, aging, brake fluid viscosity and oil volume, and replace the brake fluid with high boiling point in time to prevent high oil consumption. completely eliminate the brake system. air, etc.
三是高温软化路面
third, high temperature softened pavement
此外，高温天气使油泥路面变形，路面附加力减小，也大大降低了制动效果。
in addition, the high temperature weather makes the road surface deformed, the additional force of the road surface reduced, and also greatly reduces the braking effect.
简单讲解叉车配件以及零件的清洗
购买叉车必须注意需求
叉车销售公司告诉大家在行驶的时候，需要注意的事项
电动叉车的直流半交流全交流系统该怎么选
电动叉车技术员称对于电动堆高车品牌定位，应该注意以下几点要求：
叉车出租时如何更换叉车的电瓶
电动叉车为什么比柴油叉车贵？
叉车租赁的电动叉车选交流好还是直流好
上一篇：电动叉车是否值得购买？